2019 Mercedes-Benz Sprinter (VS30) recall: Suspension: rear, springs, leaf spring assembly, leaf
Recall at a glance
- Campaign number
- 20V426000
- Reported
- July 27, 2020
- Manufacturer
- Daimler Vans USA, LLC
- Part
- Suspension: rear, springs, leaf spring assembly, leaf
- Vehicles affected
- About 26
What is wrong
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Mercedes Benz Sprinter and Freightliner Sprinter vehicles. The incorrect leaf spring shims may have been installed between the rear axle and the leaf springs possibly affecting the vehicle's handling. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 126, "Electronic Stability Control Systems."
Safety risk
The incorrect leaf spring shims may negatively affect vehicle handling, increasing the risk of a crash.
The fix
DVUSA will notify owners, and dealers will replace the leaf spring shims on both sides, renew the spring brackets, check the rubber buffers for wear, renewing them if necessary, and adjust the headlamps, free of charge. The manufacturer has not yet provided a schedule for recall notification. DVUSA issued owners an interim notification on September 18, 2020. The recall began October 1, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3LEFSPRI.
Affected models
Model years listed by NHTSA for this campaign. Only vehicles within the build range in the notice are affected.
Notes from the notice
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Frequently asked questions
Which vehicles are affected by this recall?
Mercedes-Benz Sprinter (VS30) (2019). Check your VIN to confirm.
What is the safety risk?
The incorrect leaf spring shims may negatively affect vehicle handling, increasing the risk of a crash.
What is the fix?
DVUSA will notify owners, and dealers will replace the leaf spring shims on both sides, renew the spring brackets, check the rubber buffers for wear, renewing them if necessary, and adjust the headlamps, free of charge. The manufacturer has not yet provided a schedule for recall notification. DVUSA issued owners an interim notification on September 18, 2020. The recall began October 1, 2020. Owners may contact…
Source: U.S. National Highway Traffic Safety Administration (NHTSA) recall data for passenger vehicles, recalls since 2013, shown as published. This site is independent and not affiliated with NHTSA or any manufacturer. Check your VIN at nhtsa.gov/recalls and follow your manufacturer’s notice. Terms and disclaimer.